1. https://dealsea.com/view-deal/1370784 P@8gV+4C^h9G
2. https://dealsea.com/view-deal/1370809
Chap 1. Odyssey
左前/右后底盘可能在刹车/拐弯时响，车店说左前CV坏右后减震器漏油，后减震器均已换。卸胎手推CV alxe轴，右前轴有1mm位移左前没有。
检查PCV；-有油，清理后装回 5/10/19
换AT mount，修复滑丝的lug bolt；-done 5/10/19
如果还有响声买struts与其boot一起换；-发现AT mount缺螺母是响声源，fix后底盘数处还随机响
换后窗雨刷，发现前雨刷换成轮胎厂的东东，刷不干净 - 5/10/19
flush power steering fluid，-done 5/10/19
coolant很满;
有空用树脂修复trailing arm bushing；
换前胎strut boot；
完成android系统、USB充电/外接。-done July
===2020
1.清洗判断PS漏点，监察AT是否漏 done 10/03/20
2.换PS高压管，装回轮胎前arm加油防锈 done 10/03/20
3. PS pump seal？未漏故忽略
4.前底胶版修复，加前格栅 done 10/03/20
5. Air intake tube裂两道，已换 10/09/20
rebuild: https://www.youtube.com/watch?v=MR-6I-Ka3VQ https://www.youtube.com/watch?v=A4zpDPKPdGE kit Gates 348558或91048-P2A-003 91249-PNC-003 91345-RDA-A01 91347-RP6-A01 91347-P2A-003 91348-P2A-003 91349-P2A-00
new pump: https://www.ebay.com/itm/Power-Steering-Pump-For-2003-2013-Honda-Odyssey-Acura-MDX-Pilot-New-RGL-A03-3-7L/222633905261
idle unusual: https://www.youtube.com/watch?v=rsCFgTa8lag relearne done
4.1 EGR 18011-R70-A00 exhuast gas recycle https://www.youtube.com/watch?v=O2VLzlVe0N8 https://www.youtube.com/watch?v=e-PzkoGhv0M
4.2 MAP 37830-RNA-A01 https://www.youtube.com/watch?v=S3w9275quWE
4.3 IAC idle air control: under throttle body
4.4 throttle body gasket 16176-RCA-A02: https://www.youtube.com/watch?v=bv2WBHySwdM
4.5 intake manifold https://www.youtube.com/watch?v=c-d08c_FS1w 17105-RCA-A01) Intake Manifold Gasket
5.清洗判断机油漏点，要修也得下次换油时
air intake tube: https://www.youtube.com/watch?v=c-d08c_FS1w&t=1m35s
Timing belt: https://www.youtube.com/watch?v=GgOUMYHGHms
break: https://www.youtube.com/watch?v=7DxhysgCbMw https://www.youtube.com/watch?v=hKK7lLIkteU https://www.youtube.com/watch?v=OuG40g2ZVHI https://www.youtube.com/watch?v=DWtjM4a-39Q https://www.youtube.com/watch?v=7DxhysgCbMw
break fluid: https://www.youtube.com/watch?v=V5O_pbC8R2E https://www.youtube.com/watch?v=n1NvtUwfRJc 记住原液高度以便最后加到同样高度-高度指示刹车片的磨损程度。准备干燥的纯净水瓶里面放刹车液，透明管插入其中并连接放液口，顺序是LF/RR/RF/LR。由刹车液罐吸出大部旧液。加满新液，松开放液螺母，踩刹车踏板8-10次，拧紧放液螺母；重复此步骤直至完成。最后将新液加到之前的高度。刹车液用DOT4或DOT3，因其吸水没用完的新液要舍弃；又因其腐蚀金属和油漆，注意不要流到其它地方。
alternator: https://www.youtube.com/watch?v=vJabM9rd0Lw repaired
starter: https://www.youtube.com/watch?v=Y38_8G4Umgc&t=134s
belt: https://www.youtube.com/watch?v=F3UcmdzhNgU
A/C: https://www.youtube.com/watch?v=v1cPLog0h3k https://www.youtube.com/watch?v=FQX200Ya8i0 https://www.youtube.com/watch?v=18oRJLwkpQE
O2 sensor: https://www.youtube.com/watch?v=WSgN8JCmbIQ https://www.youtube.com/watch?v=hkQPYZK48Fs
cat: https://www.youtube.com/watch?v=IsrqfHg57Wk
new odyssey x431 s/w: https://www.youtube.com/watch?v=gVwkVLX_8D8 重置电脑ECM等
===2021
前后刹车片/break fluid均已换：Nov.1
电池正极锈断已换，松脱已加thread lock；负极螺栓吃入铜片，已加环片和垫片
尚未修理的：左前CV转弯时响，右侧motor mount，悬挂套管，机油壳漏油，放油阀门，车体多处破损。
===2022
加机油阀门, done
ATF：准备年底换 - done
===2023
TPMS battery - front done on 0303，TPMS light already off。
交换轮胎：先顶后轮用jack stands并卸掉轮胎，再顶前轮卸胎后换装原后轮胎，最后再顶后轮，将原前胎交错后装上，去掉jack stands。-done 0306
轮胎alignment：上次换新胎时没做，现在发现驾驶侧内缘磨得很厉害。-证实该处toe超出很多，店铺建议40psi。done 0307
检查AT mounts下螺栓是否丢失：顶前轮用jack stands。顺便上下左右检查轮胎晃动。检查tensioner有否漏油。
change psg side motor mount；底部去油
更换驾驶侧CV axle - 咯咯声换后消失，done 230401
乘客测CV axle取下换boot卡环和油脂 ？
master door switch replace - done
rear air actuator - done 070723
Front struts - https://www.youtube.com/watch?v=mtinmBtYHGg#t=5m
front doors checker repalce - cancelled
coolant temp sensor 2 - wire bit by squirrel， repaired
coolant - wait for kit
replace PS fulid -?
air filter
Chap 2. GS300
底盘在刹车放松时响，65迈以上方向盘车震，支车晃轮胎检查engine mount，tie rod，struts及其它悬挂部件；拆lower control arm 2，用树脂修复，等24小时候重装；-done 5/9/19，雨季前换了4胎做alignment，震动消失
检查后engine mount完好，tie rod与truts均未漏油；-done 5/8/19
oil pan漏油，不知是否因此次没用high mileage，待换
===2020
1.清洗了，待判断机油漏点：cam/crank shaft seal，cam gear o-ring，valve cover gasket， oil pan gasket？
2.motor mount？
3.清洗并用 Plastic dip修复Strut boot - done, 估计不如换有效https://www.youtube.com/watch?v=xG8OdyMaWsE
Valve gasket&Spark plug: https://www.youtube.com/watch?v=Ktc1hzWEmyw https://www.youtube.com/watch?v=Ktc1hzWEmyw&list=RDQMA1bu0y3sEII&start_radio=1 https://www.youtube.com/watch?v=rSRifJF2aOA
cam o-ring: https://www.youtube.com/watch?v=8Ht4ckuj_qI 视频比这个简单：https://www.youtube.com/watch?v=4EKGT04wpAg
Diffrential fluid: https://www.youtube.com/watch?v=xCvMGzY7f3I
TB&cam/valve seals:https://www.youtube.com/watch?v=pQJKDv6SiWs https://www.youtube.com/watch?v=_GQI0QF8s5s
front/rear struts: https://www.youtube.com/watch?v=cDVpRD5hrTw https://www.youtube.com/results?search_query=GS300
Exhaust Manifold and Cats: https://www.youtube.com/watch?v=EmbG_TGIdqE
===2021
装Android - done
前座出风口有时鸡鸡格格响，需润滑重装 - 已换部件 2022.12
front/rear break: https://www.youtube.com/watch?v=fyzx7xLu88w https://www.youtube.com/watch?v=nLzftkRjH3 刹车片前面3-4mm，后面60% - 2021.11.1
===2022
前后刹车片均已换，Differential fluid已换
火花塞、汽缸盖密封、PCV 已换 2022/10/20
换驾驶侧后门actuator。前门玻璃卡子重新上胶忘了哪年做的，2-3年了工作良好。
ATF: flush一次忘了时间 - changed
===2023
ext TPMS installed - 0303
检查晃动声：LCA，sway bar, tie rod, 前后strut有否漏油 - Lower control arm drv side
1) rear drv side lug bolt slipped one -04/25 done nut repalced
2) Oil pan gasket leak -04/29 done
3) VVTi gear o-ringt -leak -04/30 done，new oil/filter
4) L/R front lower control arm No.2 - done 05/12, ABS sensor replaced
5) CAM/Crank shaft seals -leak -end of May? - most difficult
6) Hood/fender paint -done 10/2023
7) right side air bag sensor - resoldered wires bit by squirrel
8) Passenger side back door rubber seal broken -
9) PS fluid ?
10) air filter
|
